Nsu Sports P1642 Engine Trouble Code
What is Nsu Sports P1642?
Nsu Sports P1642 indicates potential catalytic converter failure. If completely failed, your vehicle may not run properly and fuel economy will suffer significantly. Average replacement cost is $2,000–$2,140. This repair requires professional service and should not be delayed.
P1642 on the Nsu Sports
The Nsu Sports has a known weak point in the lambda sensor wiring loom where it passes through the floor pan grommet. Road salt and vibration cause the insulation to crack at this point, creating an intermittent open circuit that stores P1642 without a consistent symptom.
Code Information
| Code Type: | OBD-II Powertrain (P) Trouble Code |
| System: | Powertrain |
| Vehicle: | Nsu Sports |
| Brand: | Nsu |
| Model: | Sports |
| Code: | P1642 |
P1642 Nsu Sports Symptoms
Check Engine Light
Illuminated Nsu Sports dashboard warning
Engine Stalling
Engine stops unexpectedly or misfires
Performance Issues
Reduced power or acceleration on the Nsu Sports
Starting Problems
Difficulty starting the engine
Poor Fuel Economy
Increased fuel consumption on the Nsu Sports
Increased Emissions
Failed emissions test due to P1642
P1642 Code Structure
Understanding what each digit means in the P1642 powertrain trouble code:
| P | 1 | 6 | 4 | 2 |
|---|---|---|---|---|
| Powertrain Code | Fuel And Air Metering | Fuel Temperature Sensor B Circuit Range/Performance | Injection Pump Fuel Metering Control 'B' High | Glow Plug/Heater Circuit 'A' Malfunction |
How to Fix Nsu Sports P1642
Diagnostic Steps:
The catalytic converter has oxygen sensors before and after it. When warm and in closed-loop mode, the upstream O2 sensor reading should fluctuate, while downstream should remain steady.
Repair Solution:
A/C pressure sensor monitors refrigerant pressure changes. DTC sets when pressure change falls outside calibration. Verify A/C system function, refrigerant charge, and electrical connections.
Technical Notes:
For P1642, verify VCT solenoid operation. Look for stuck or sticking valves caused by contamination. Consult vehicle-specific repair manual for proper component testing procedures.
Nsu Sports P1642 Repair Cost
Intercooler hose replacement on turbocharged Nsu Sports models costs $120–$250 per section. A boost-leak smoke test ($50–$80) is the definitive diagnostic method and will pinpoint exactly which hose or connection is at fault before any parts are ordered.
P1642 Description
P1642 engine trouble code is related to Glow Plug/Heater Circuit 'A' Malfunction.
Main Cause
The primary reason for P1642 OBD-II Engine Trouble Code is: Fuel Temperature Sensor B Circuit Range/Performance.
Common P1642 Misdiagnosis on the Nsu Sports
When Nsu Sports presents P1642 with a concurrent coolant temperature DTC, technicians sometimes replace the thermostat rather than the coolant temperature sensor (CTS). The CTS is a $15–$25 component; the thermostat job carries 1–2 hours of additional labour.
DIY Repair Guide: P1642 on Nsu Sports
Battery terminal cleaning on the Nsu Sports is a 5-minute job that resolves a surprising number of P1642 intermittents. Use a wire brush and a bicarbonate of soda solution to clean corrosion, then apply a thin coat of petroleum jelly to the terminals after refitting.
Preventing P1642 on the Nsu Sports
Spark plug replacement at the manufacturer's interval — typically 30,000–60,000 miles depending on plug type — is the single most cost-effective preventive maintenance item for avoiding P1642 on the Nsu Sports.
Frequently Asked Questions — Nsu Sports P1642
A: Simple fixes like a purge valve or gas cap replacement take under an hour. Sensor replacements typically require 1–2 hours of shop time. More involved repairs like VVT actuators or catalytic converters may require a full day or more.